Avalon-stoves Avalon Pellet Stove Astoria PS Uživatelský manuál

AstoriaPellet Stove• Horizontal Or Vertical Vent• Freestanding Stove• Mobile Home Approved• Class A Chimney Retrofit• Hearth Stove into ExistingMason

10 InstallationTravis Industries 4050225 100-01154Pellet Vent Type• Must be 4" diameter Type "L"(except for masonry fireplace installat

Installation 11Travis Industries 4050225 100-01154Mobile Home Requirements• Outside air is required (used forcombustion) - see the directionsbelow.• T

12 InstallationTravis Industries 4050225 100-01154Alcove Installation RequirementsWhen the pellet stove is placed in a location where the ceiling heig

Installation 13Travis Industries 4050225 100-01154Installation Example: Direct "Through-the-wall" Installation3” Minimum9” MinimumFloor Prot

14 InstallationTravis Industries 4050225 100-01154Installation Example: Interior Vertical InstallationType "L" Vent6” Minimum3” MinimumFloo

Installation 15Travis Industries 4050225 100-01154Installation Example: Class A Chimney RetrofitType "L" Vent6” Minimum3” MinimumFloor Prote

16 InstallationTravis Industries 4050225 100-01154Installation Example: Masonry Fireplace Hearth StoveOutside air may be drawn from the ash cleanout.6

Installation 17Travis Industries 4050225 100-01154Installation Example: Zero-Clearance (Metal) Fireplace Hearth Stove“L” Vent Flex Section6” Min.“L”

18 InstallationTravis Industries 4050225 100-01154Installation Example: Freestanding Masonry Chimney“L” Vent Sections6” Min.“L” VentStorm CollarVertic

Operation 19Travis Industries 4050225 100-01154Safety NoticeRead this entire manual (especially the "Safety Precautions" on pages 4 and 5)be

2 IntroductionTravis Industries Heritage PS 270603IntroductionWe welcome you as a new owner of an Astoria pellet heater. In purchasing an Astoria you

20 OperationTravis Industries 4050225 100-01154Loading PelletsLift the hopper lid to its vertical position. Pour pellets into the hopper until full.

Operation 21Travis Industries 4050225 100-01154Manual ModeManual mode requires the user to turn theheater on and off manually.To StartPress the "

22 OperationTravis Industries 4050225 100-01154Auto ModeAuto mode allows you to use a thermostat to control room temperature. The stove automatically

Operation 23Travis Industries 4050225 100-01154Restrictor AdjustmentThe exhaust restrictor “fine tunes” your appliance, adjusting the amount of air fl

24 OperationTravis Industries 4050225 100-01154Start-Up SequenceThis stove utilizes a start-up sequence whenever the mode switch is changed or the hea

Maintenance 25Travis Industries 4050225 100-01154Daily Maintenance (whenever using the stove)Inspect the BurnWhen burning on high, theflames should be

26 MaintenanceTravis Industries 4050225 100-01154Daily Maintenance (whenever using the stove) - ContinuedCheck Firepot forClinkersIf the flames seem t

Maintenance 27Travis Industries 4050225 100-01154Door OpeningWARNING : Make sure the heater has fully cooled (approximately 25 minutes) before open

28 MaintenanceTravis Industries 4050225 100-01154Bi-Weekly Maintenance (or every 10 bags of pellets)Clean the Heat Exchange TubesHeat Exchanger Cleani

Maintenance 29Travis Industries 4050225 100-01154Bi-Weekly Maintenance (or every 10 bags of pellets) - ContinuedClean the BafflesUse both hands to lif

Table of Contents 3Travis Industries 4050225 100-01154IntroductionIntroduction...2Important Informa

30 MaintenanceTravis Industries 4050225 100-01154Sweep Ash Into AshpanHINT: The more often you clean out the flyash, the more efficient your heater wi

Maintenance 31Travis Industries 4050225 100-01154Bi-Weekly Maintenance (or every 10 bags of pellets) - ContinuedCheck Ashpan, Dispose if necessaryNOTE

32 MaintenanceTravis Industries 4050225 100-01154Yearly Maintenance (or every two tons)WARNING: Disconnect the power cord prior to conducting service.

Maintenance 33Travis Industries 4050225 100-01154Yearly Maintenance (or every two tons) - ContinuedClean the Exhaust Blower (make sure the stove is co

34 MaintenanceTravis Industries 4050225 100-01154Yearly Maintenance (or every two tons) - ContinuedDoor Seal! Air leaks into the firebox will decrease

Maintenance 35Travis Industries 4050225 100-01154Adjusting the Door Hinge and Latch• The door hinge and door latches may be adjusted to pull the door

36 MaintenanceTravis Industries 4050225 100-01154Check for Air Leaks Around the Door, Glass, and Ashpan! Air leaks into the firebox will decrease the

Normal Operating Sounds 37Travis Industries 4050225 100-01154Auger MotorWhen feeding pellets, you may hear the intermittent buzz of this motor running

38 Safety LabelTravis Industries 4050225 100-01154WARNING - DO NOT REMOVE OR COVER THIS LABELListed PelletizedSolid Fuel Burning ApplianceAlso for Use

Limited 7 Year Warranty 39Travis Industries 4050225 100-01154To register your TRAVIS INDUSTRIES, INC. 7 Year Warranty, complete the enclosed warranty

4 Safety PrecautionsTravis Industries 4050225 100-01154• Do not operate theheater if you smellsmoke coming fromthe heater. Turn theMODE switch to&qu

40 Optional EquipmentTravis Industries 4050225 100-01154Thermostat (Part # 99300650)! Do not connect 120 VACto the thermostat circuit ofthis heater (d

Optional Equipment 41Travis Industries 4050225 100-01154 Remote ThermostatFollow the instructions included with the remote thermostat for installation

42 IndexTravis Industries 4050225 100-01154Adjusting the Fan Speed...23Air Leaks...

Safety Precautions 5Travis Industries 4050225 100-01154• The heater will not operateduring a power outage. Ifa power outage doesoccur, check the hea

6 SpecificationsTravis Industries 4050225 100-01154Heating Specifications:Approximate Maximum Heating Capacity (in square feet)*...

Installation 7Travis Industries 4050225 100-01154Before You BeginREAD THIS ENTIRE MANUAL BEFORE YOU INSTALL AND USE THIS HEATER.FAILURE TO FOLLOW THE

8 InstallationTravis Industries 4050225 100-01154Clearances - Straight Installation6” Minimum3” Minimum9” Minimum3” MinimumThrough the Wall Installati

Installation 9Travis Industries 4050225 100-01154Venting the Pellet Stove• PELLET VENT MUST MAINTAIN A MINIMUM 3" CLEARANCE TO ANYCOMBUSTIBLE (IN